Vessel Forms Page
Home Page
Ferry Engineer Handover Report
Date Handover Report Started
2016-01-27
Last day of swing
Vessel Name
Capricornian Spirit
Brahminy Kite
Bruce
Canaipa
Capricornian Spirit
Freedom Monarch
Goodna
James Grant
Maintenance
Minjerribah
MOT
Nancy Wake
Office
Palm Cat
Parangool
Pontoon
QC1
Quandamooka
Reef Quest
Shute Harbour
Slipway Pontoon
Sun Harmony
Sun Serenity
Sun Symphony
Torresian
Trojan
Vessel Staus
Operational and ready for runs. Seacocks off, batteries isolated.
Fuel
Water
Black Water
Grey Water
Waste Oil
Bilge Water
Bridge Equipment
Operational
General Navigational Equipment
Radios, Sounders, AIS, Furuno equipment
Yes\
No\ Comments
Steering Controls Main
Yes\
No\ Comments
Steering Controls Beckup
Yes\
No\ Comments
Bucket controls 1, 2, 3 & 4
Yes\
No\ Comments
CCTV System
Yes\
No\ Comments
CCTV Hull Cameras
Yes\
No\ Comments
Nav Lights
Yes\
No\ Comments
Public Address system
Yes\
No\ Comments
Fire system
Yes\
No\ Comments
Port fwd alarm light not operational
Search Light / Fleur System
Yes\
No\ Comments
Intercom System
Yes\
No\ Comments
Lighting
Yes\
No\ Comments
Toilet light not working, Breaker tripping, MRF submitted.
Air Conditioner W/House
Yes\
No\ Comments
Window Wiper Fwd
Yes\
No\ Comments
Window Wiper Aft
Yes\
No\ Comments
Water Tight Door engine rooms and deck hatches
Yes\
No\ Comments
UHF Hand held sets x5
Yes\
No\ Comments
AMS-PLC System/Issues
Yes\
No\ Comments
Engineering
Operational
Main Engine 1
Yes\
No\ Comments
Main Engine 2
Yes\
No\ Comments
Main Engine 3
Yes\
No\ Comments
Main Engine 4
Yes\
No\ Comments
0
Generator 1
Yes\
No\ Comments
Generator 2
Yes\
No\ Comments
Port Engine Fire Pump Room
Yes\
No\ Comments
Starboard Engine Fire Pump Room
Yes\
No\ Comments
Portable Domestic water pumps 1, 2 and 3
Yes\
No\ Comments
Bilge water pumps & Alarm Systems
Yes\
No\ Comments
Sewerage Pump
Yes\
No\ Comments
Ventilation Fans
Yes\
No\ Comments
Battery's onboard condition
Yes\
No\ Comments
Air Conditioners Fwd Main Cabin
Yes\
No\ Comments
Air Conditioners Aft MainCabin
Yes\
No\ Comments
Air Conditioners Upper Cabin
Yes\
No\ Comments
Air Conditioners Wheel house
Yes\
No\ Comments
Refridgerator Wheel House
Yes\
No\ Comments
Microwave Wheel House
Yes\
No\ Comments
MPM Issues
Yes\
No\ Comments
Engineering Maintenance requests/urgent
Yes\
No\ Comments
See notes below
Engineering Stores requests/urgent
Yes\
No\ Comments
General Comments
Please enter the Content
<p><strong><u>G’day Craig,</u></strong></p> <p>A very, very busy swing for us with many engineering jobs, lots of training (again!) and changes to schedules etc. at different times.</p> <p><strong><u>Major works completed this swing:</u></strong></p> <ol> <li>a. 8/1/15 Removed, cleaned and replaced Port Fwd M/E flow monitor, working fine.</li> </ol> <p> b. 8/1/15 Stbd Aft Lower Deck Aircon Cassette Unit capacitor replaced, working fine.</p> <p> c. Fitted cyclone mooring bridle and went to cyclone moorings to manufacture and fit the tethering lines to the moorings for all 35m vessels – see emails from Jeff, these need to be checked weekly.</p> <ol> <li>11/1/16 Starboard Power Conditioner Failure occurred, operated vessel successfully on backups to complete runs, replaced conditioner and fitted covers above to stop water ingress from hatches to topsides of conditioners. All running fine.</li> <li>12/1/16 Stbd Mains Serviced, Anodes replaced, impellers checked. Changed Port and Stbd Jet Bearing oils.</li> <li>13/1/16 Port Mains Serviced, Anodes replaced, impellers checked (port aft impeller replaced), house batteries tested, Bilge Pumps and alarms tested in all voids.</li> <li>15/1/16 New Turbo fitted to Port aft M/E as still burning coolant, no issues recurring.</li> <li>19/1/16 Removed and replaced Stbd Aft Exhaust manifold and turbo as showing same symptoms as Port Aft was before fixing (burning coolant), stripped down and cleaned heat exchanger, replaced rear side cover gasket, replaced thermostat in after cooler.</li> <li>20/1/16 New door handle fitted to Port Aft door on lower deck.</li> <li>21/1/16 Barney Busted all engines, new impellers installed.</li> <li>a. 22/1/16 Painted Port Aft Coolant Manifold on M/E.</li> </ol> <p> b. 22/1/16 All overboard discharge valves closed as per Jeff’s email 21/1/16.</p> <p> 10. 25/1/16 Stbd Genset failure, replaced impellor, removed broken fins from impeller fromheat exchanger, found coolant temperature sensor faulting, cleaned connections and ordered new sensor.</p> <p> </p> <p><strong><u>New MRFs requiring attention:</u></strong></p> <p style="margin-left:35.45pt">#2133 – Stbd Mid Fwd Air con not operating properly – showing light sequence on timer light concurrent with water pump failure.</p> <p style="margin-left:35.45pt">#2134 – Port fwd fire alarm box in engine room light not flashing on alarm test mode.</p> <p style="margin-left:35.45pt">#2137 – Raw water leak on manifold directly under the air filter on port aft m/e. Richard should be here to fix this today 27/1/16 or tomorrow.</p> <p style="margin-left:35.45pt">#2149 - Toilet lights and fans breaker (#4) tripping out, 27/01/16</p> <p style="margin-left:18.0pt"><strong><u>Other business and misc.</u></strong></p> <p style="margin-left:18.0pt">We fuelled up yesterday as you can see in the log, fresh is topped up and sullage empty!</p> <p style="margin-left:18.0pt">Mains are a little overfull with oil following servicing but have checked with Richard and he said this was fine and to let the engines “do their thing”. All other fluids within correct, acceptable levels. All bilges cleaned where possible and new pads replaced. Port side is awaiting the replacement of the gasket to fix the leak as per MRF #2137 mentioned above. I haven’t replaced the pads in that side as they will get soaked with salt water when the leak is fixed. I put this MRF in on Saturday but Richard has been very busy with other vessels so hasn’t had time to get it fixed. I vacuumed this side this morning but it may well have water in it again if Richard has been down to fix the leak. Hopefully the toilet fans and lights breaker has ben fixed, this only presented itself this morning.</p> <p style="margin-left:18.0pt">Jet rams greased as per log (Monday 25/1/16), and jet rooms cleaned, degreased and pads replaced.</p> <p style="margin-left:18.0pt">Please call with any questions mate - 0410 678 459.</p> <p style="margin-left:18.0pt">Have a fantastic swing and hoping it’s not quite as ‘eventful’ as ours!</p> <p style="margin-left:18.0pt"><strong><u>Batteries are isolated and main seacock valves are shut.</u></strong></p> <p style="margin-left:18.0pt">Regards to you, your family, Des and the crew, <strong><u>Tony.</u></strong></p> <p> </p>
Name Of Person completing Hand Over
Authorisation Code
